Misplaced Pages

The Blaw-Knox company was an American manufacturer of steel structures and construction equipment based in Pittsburgh, Pennsylvania. The company is today best known for its radio towers, most of which were constructed during the 1930s in the United States. Although Blaw-Knox built many kinds of towers, the term Blaw-Knox tower (or radiator) usually refers to the company's unusual "diamond cantilever" design, which is stabilized by guy wires attached only at the vertical center of the mast, where its cross-section is widest. During the 1930s AM radio broadcasting stations adopted single mast radiator antennas, and the Blaw-Knox design was the first type used. A 1942 advertisement claims that 70% of all radio towers in the United States at the time were built by Blaw-Knox.

The distinctive diamond-shaped towers became an icon of early radio. Several are listed on the United States National Register of Historic Places, the distinctive diamond antenna design has been incorporated into logos of various organizations related to radio and a very large (scale) replica of the WSM (AM) Blaw-Knox tower has been built into the Country Music Hall of Fame and Museum.

Design

The diamond-shaped tower was patented by Nicholas Gerten and Ralph Jenner for Blaw-Knox July 29, 1930. and was one of the first mast radiators. Previous antennas for medium and longwave broadcasting usually consisted of wires strung between masts, but in the Blaw-Knox antenna, as in modern AM broadcasting mast radiators, the metal mast structure functioned as the antenna. To prevent the high frequency potential on the mast from short-circuiting to ground, the narrow lower end of the tower rested on a ceramic insulator about three-foot wide, shaped like a ball and socket joint. Thus, the tower required guy-wires to hold it upright.

The distinguishing feature of the Blaw-Knox tower was its wide diamond (or rhomboidal, rhombohedron) shape, which served to make it rigid, to resist shear stresses. One advantage of this was to reduce the number of guys needed. Blaw-Knox masts required only one set of three or four guys, attached at the tower's wide "waist". In contrast, narrow masts require two to four sets of guys, attached at different heights, to prevent the tower from buckling. The advantage of fewer guys was to simplify the electrical design of the antenna, because conductive guys interfered with its radiation pattern. The guys acted as "parasitic" resonant elements, reradiating the radio waves in other directions and thus altering the antenna's radiation pattern. In some Blaw-Knox mast designs (see WBT towers, right) the upper pyramidal section was made longer than the lower, to keep the attachment point of the guys as low as possible, to minimize their interference.

Another advantage mentioned in the patent was that the tower could be erected in two parts. Half of the mast could be built, then its wide central section could be used as a stable base on which to erect the other half.

A disadvantage of the diamond mast shape was that the current distribution on the tower caused less radio power to be radiated in horizontal directions and more at an angle into the sky, compared to a slender uniform width mast. Since AM radio stations covered their listening areas with ground waves, radio waves that traveled horizontally close to the ground surface, this meant the listening area was smaller. The realization of the nonideal radiation pattern of the design caused the diamond-shaped tower to fall out of favor in the 1940s in radio stations, replaced by the narrow uniform width lattice mast used today.

Gallery

• 1939 company advertisement
• 1955 company advertisement
• Lakihegy Tower, a 314-metre (1030 ft) Blaw-Knox mast at Szigetszentmiklós-Lakihegy, Hungary
• WSM 808-foot (246 m) tower, in the Nashville, Tennessee suburb of Brentwood, is the tallest in the United States.
• WLW's Blaw-Knox tower has been in use since 1934.
• WBT 428–ft (130 m) towers, just south of uptown Charlotte, North Carolina.
• Vakarel radio transmitter
• WBNS 380 ft tower in Columbus, Ohio

List of Blaw-Knox towers

Many Blaw-Knox towers, of both conventional (uniform cross-section) and diamond design, remain in use in the United States. Few of the diamond towers were built, and several remain; all transmit AM radio signals. The most well-known example in Europe is the Lakihegy Tower, located in Szigetszentmiklós-Lakihegy, Hungary. Several additional diamond cantilever towers were built at stations in the Central Valley of California, but are less well known. These towers were much smaller in both height and cross-section than the towers listed elsewhere; only one — KSTN, Stockton — remains in use for broadcasting.

In the following chart:   structure is no longer standing.   structure has changed height.   rebuilt structure.

Three other Blaw-Knox towers of unknown heights also used to exist but have since been removed for the following stations: WABC in Wayne, N.J.; WCAU in Newtown Square, Pennsylvania; and WHO in Des Moines, Iowa.

Blaw-Knox also constructed a 469-foot (143 m) tall tower in 1948 for WKQI (then known as WLDM) located on Ten Mile Road in the Detroit suburb of Oak Park, Michigan. However, unlike its namesake diamond cantilever form, this structure was built as a conventional four-sided self-supporting lattice tower.

See also

• Radio masts and towers
• Blawnox, Pennsylvania

Notes

1. WLW's antenna is featured on the official seal of the City of Mason. Designed and erected by the Blaw-Knox Tower company in 1934, it was the second of its type to be built, after WSM's, and is one of eight still operational in the United States.

References

1. ^ "Half Wave Mast Antenna: A 665 foot structure which constitutes a new departure" (PDF). Radio-Craft. 3 (5). Mount Morris, Illinois: Techni-Craft Publishing Corp.: 269 November 1931. Retrieved August 31, 2014.
2. Blaw-Knox Division of Blaw-Knox Company. "On duty for the duration (advertisement)". Broadcasting and Broadcast Advertising. 22 (19). Washington, D.C.: Broadcasting Publications, Inc.: 104.
3. WSM tower gets 'historic' status, The Tennessean, April 14, 2011
4. "Weekly list of actions taken on properties: 3/14/11 through 3/18/11". National Park Service. March 25, 2011. Retrieved March 26, 2011.
5. US patent 1897373, Nicholas Gerten, Ralph Lindsay Jenner, Wave Antenna, filed July 29, 1930, granted March 14, 1933
6. Siemens, Frederick (December 1931). "WABC's New "Wire-less" Antenna" (PDF). Radio News. 8 (6). New York: Teck Publishing Corp.: 462–463. Retrieved May 26, 2015.
7. Blaw-Knox advertisement, Broadcasting, March 1, 1939, page 41.
8. Blaw-Knox advertisement, Broadcasting, July 18, 1955, page 79.
9. Fybush, Scott (2005-11-18). "The Historic AMs of Stockton, California". Fybush.com. Retrieved 2009-01-19.
10. "Lakihegy Blaw-Knox Radio Tower, Budapest | 1226375 | EMPORIS". Archived from the original on 2021-02-05.{{cite web}}: CS1 maint: unfit URL (link)
11. "Liblice Blaw-Knox Tower, Liblice | 1226311 | EMPORIS". Archived from the original on 2021-02-04.{{cite web}}: CS1 maint: unfit URL (link)
12. "Vakarel Blaw-Knox Radio Mast, Elin Pelin | 1226448". Emporis. Archived from the original on March 7, 2022. Retrieved 2022-05-03.{{cite web}}: CS1 maint: unfit URL (link)
13. ???????? ?? ???????? ?? ???????, 16.09.2020 ?. YouTube. Archived from the original on 2021-12-10.
14. "Jim Hawkins' WADO Transmitter Page".
15. "LVRTC Riga Blaw Knox Radiator, Riga | 1226603". Emporis. Archived from the original on March 7, 2022. Retrieved 2022-05-03.{{cite web}}: CS1 maint: unfit URL (link)
16. "WFEA Blaw-Knox Radiator, Manchester - SkyscraperPage.com".
17. "Stara Zagora Blaw-Knox Radio Mast, Stara Zagora | 1226457". Emporis. Retrieved 2022-05-03.
18. ^ "A selection from a decade of visits to tower and studio sites in the Northeast and beyond".
19. "Blaw-Knox Diamond Radio Towers (Jim Hawkins Radio and Broadcast Technology Page)".
20. Antenna Structure Registration 1007142 FCCInfo.com, a service of Cavell, Mertz & Associates, Inc. Retrieved 2020-08-15.

External links

• Blaw-Knox Technical Origins
• Archived 2020-02-21 at the Wayback Machine

• Telecommunications equipment
• Radio masts and towers in the United States