Misplaced Pages

TransAsia Airways Flight 791

B-22708, the ATR 72-200 involved, photographed just four months before the accident
Accident
Date	21 December 2002 (2002-12-21)
Summary	Atmospheric icing and pilot error leading to loss of control
Site	17 kilometres (11 mi; 9.2 nmi) southwest of Magong, Penghu, Taiwan
Aircraft
Aircraft type	ATR 72-202
Operator	TransAsia Airways
IATA flight No.	GE791
ICAO flight No.	TNA791
Call sign	TRANSASIA 791
Registration	B-22708
Flight origin	Chiang Kai Shek International Airport (now Taoyuan International Airport), Taipei, Taiwan
Destination	Macau International Airport, Macau
Occupants	2
Passengers	0
Crew	2
Fatalities	2
Survivors	0

TransAsia Airways Flight 791 was a regular cargo flight between Chiang Kai Shek International Airport (now Taiwan Taoyuan International Airport) and Macau International Airport. At 01:52 am local time on 21 December 2002, the ATR 72 operating the flight crashed into the sea 17 kilometres (11 mi; 9.2 nmi) southwest of Magong, Penghu, Taiwan. The two crew members on board were killed.

Accident

Flight GE791 was operated using an ATR 72-200 freighter. The captain and first officer were the only occupants of the aircraft. The flight was from Chiang Kai Shek International Airport (now Taoyuan International Airport) to Macau International Airport.

Flight 791 departed from Taoyuan at 1:04 am local time (17:04 UTC). At 1:51 am, the first officer requested permission from Air Traffic Control (ATC) to descend from flight level (FL) 180 (18,000 feet (5,500 m)) to FL160 (16,000 feet (4,900 m)). The controller approved the request and the first officer acknowledged. However, the aircraft began a rapid descent and disappeared from the radar screens one minute later, at 01:52 am. The last known position of the aircraft was about 17 kilometres (11 mi; 9.2 nmi) southwest of Magong, Penghu.

At 03:05 am, the Civil Aeronautics Administration of the Ministry of Communications of Taiwan declared an emergency and dispatched helicopters and boats of the Air Force, Navy and Coast Guard Administration to search for Flight 791.

At 08:05 one of the rescue boats found the first pieces of debris and subsequently confirmed that Flight 791 had crashed. It is not known if the bodies of the flight crew were recovered. The captain was presumed dead by a court.

Aircraft and crew

The aircraft involved was an ATR 72-200 (registration B-22708, manufacturing serial number 322). It entered service as a passenger aircraft with TransAsia Airways on 25 August 1992.

From September 1998 to February 2001, the aircraft was leased to Gill Airways in the United Kingdom with British registration G-BXYV. After returning to TransAsia Airways in 2001, the aircraft was converted into a freighter and was given its previous registration back as B-22708.

At the time of the accident, the aircraft had 19,254 hours, and 25,529 takeoff and landing cycles. The aircraft was powered by two Pratt and Whitney PW124B engines.

Captain Pan Teh-chung, aged 53, had been with TransAsia Airways since 1991. He had 14,277 hours of flight experience, including 10,608 hours on the ATR 42/72. First Officer Liu Ching-hai, aged 34, had been with TransAsia Airways since 1997 and had logged 4,578 flight hours, with 4,271 of them on the ATR 42/72.

Investigation

This section needs expansion with: more information from the report. You can help by adding to it. (May 2019)

Taiwan's Aviation Safety Council (now the Taiwan Transportation Safety Board) investigated the accident. The ASC reviewed the flight crew's training records. During recurrent training, the captain had "satisfactory" scores in icing conditions, however the instructor noted that the captain had a "tendency to lose situational awareness". According to his instructor, the captain repeated the training, and his results improved. Despite this, the instructor said that the captain was "still unsteady." There were no issues reported during the first officer's training.

Salvage and recovery

The majority of the wreckage was found 180 metres (590 ft) away from where Flight 791 last made contact with ATC. On 9 January 2003, the ASC commenced a salvage operation assisted by the coast guard administration and TransAsia Airways staff. The first salvage operation was performed on 10 January, after being delayed due to weather. The flight data recorder (FDR) was recovered on 11 January, and the cockpit voice recorder (CVR) was recovered on 14 January.

Examination of wreckage

This section needs expansion with: more information from the report. You can help by adding to it. (May 2019)

Investigators discovered ice accumulation around the aircraft's major components. The aircraft's de-icing system was examined as well.

Analysis of the flight recorders

The CVR recorded a large amount of non-pertinent conversation. The first indication of any problem occurred at 1:34 am, when a "single chime" caution was heard. The captain then explained about how ice was accumulating on the aircraft at 1:44. The captain then brought this up a second time at 1:50. The crew then requested their descent. A short non-pertinent conversation was then heard, after which several alarms sounded until the end of the recording.

The FDR indicated that the autopilot was disengaged at the moment of impact. The anti-ice system had been activated twice. The first was from 1:34 to 1:37, and the second was from 1:41 until the accident.

Sequence of events based on recorder analysis

This section needs expansion with: more information from the report. You can help by adding to it. (May 2019)

Flight 791 was normal until 1:34 am with the "single chime" alert going off. At 1:44 the captain said, "It’s iced up quite a huge chunk," and then four minutes later shouted, "Wow it’s a huge chunk," to which the first officer responded "what an ice," followed by, "this speed is getting slower it was a hundred two hundred one hundred and ninety now one hundred seventy." The captain expressed concern to the first officer about the pitot-static system getting blocked but he did not express the concern of the aircraft stalling. He also requested that they should descend as a precaution. After the first officer requested and obtained clearance to descend by ATC, the captain again said that there was ice accumulating on the aircraft. The stick shaker then activated, followed by the aural stall warning. The autopilot was disengaged in an attempt to recover the aircraft, which had entered an aerodynamic stall. The attempt was unsuccessful and the aircraft rapidly lost altitude and crashed into the Ocean, killing the crew.

Conclusion

The Aviation Safety Council released its final report on 25 October 2003. The report determined that the flight crew had lacked situational awareness and thus did not respond to the severe icing conditions.

Findings related to probable causes:

1. The accident flight encountered severe icing conditions. The liquid water content and maximum droplet size were beyond the icing certification envelope of FAR/JAR 25 Appendix C.
2. TNA's training and rating of aircraft severe icing for this pilots has not been effective and the pilots have not developed a familiarity with the note, CAUTION and WARNING set forth in Flight Crew Operating Manual and Airplane Flight Manual to adequately perform their duties.
3. After the flight crew detected icing condition and the airframe de-icing system was activated twice, the flight crew did not read the relative handbook, thereby the procedure was not able to inform the flight crew and to remind them of "be alert to severe icing detection".
4. The "unexpected decrease in speed" indicated by the airspeed indicator is an indication of severe icing .
5. The flight crew did not respond to the severe Icing conditions with pertinent alertness and situation awareness that the aircraft might have encountered conditions which was "outside that for which the aircraft was certificated and might seriously degrade the performance and controllability of the aircraft".
6. The flight crew was too late in detecting the severe icing conditions. After detection, they did not change altitude immediately, nor take other steps required in the Severe Icing Emergency Procedures.
7. The aircraft was in an "unusual or uncontrolled rolling and pitching" state, and a stall occurred thereafter.
8. After the aircraft had developed a stall and an abnormal attitude, the recovery maneuvering did not comply with the operating procedures and techniques for Recovery of Unusual Attitudes. The performance and controllability of the aircraft may have been seriously degraded by then. It cannot be confirmed whether the unusual attitudes of the aircraft could have been recovered if the crew's operation had complied with the relevant procedures and techniques.
9. During the first 25 minutes, the extra drag increased about 100 counts, inducing a speed diminishing about 10 knots.
10. During the airframe de-icing system was intermittently switched off, it is highly probable that residual ice covered on the wings of the aircraft.
11. Four minutes prior to autopilot disengaged, the extra drag increased about 500 counts, and airspeed decayed to 158 knots, and lift-drag ratio loss about 64% rapidly.
12. During the 10s before the roll upset, the longitudinal and lateral stability has been modified by the severe ice accumulated on the wings producing the flow separation. Before autopilot disengaged, the aerodynamic of the aircraft (lift/drag) was degraded of about 40%.

— ASC final report

See also

• American Eagle Flight 4184 - another ATR 72 that crashed after a loss of control due to atmospheric icing.

References

1. ^ "Inflight icing encounter and crash into the sea, TransAsia Airways Flight 791, ATR72-200, B-22708, 17 kilometers Southwest of Makung City, Phengu Islands, Taiwan, December 21, 2002" (PDF). Aviation Occurrence Report. 1. Taipei, Taiwan: Aviation Safety Council. 25 October 2003. ASC-AOR-05-04-001. Retrieved 25 May 2019.
2. "CI611與GE791失事殘骸偵搜打撈作業比較" [Comparison of CI611 and GE791 wreckage and reconnaissance] (PDF) (in Chinese). Archived from the original (PDF) on 22 March 2014.
3. "Investigation page (with links to the report and appendices)". Aviation Safety Council. Archived from the original on 22 March 2014. Retrieved 22 March 2014.
4. ^ Ranter, Harro. "ASN Aircraft accident ATR 72-202 B-22708 Makung City, Penghu Islands". aviation-safety.net. Retrieved 25 May 2019.
5. "B-22708 TransAsia Airways ATR 72". www.planespotters.net. Retrieved 10 June 2020.
6. "Transasia Airways B-22708 (ATR 42/72 - MSN 322) (Ex G-BXYV)". www.airfleets.net. Airfleets aviation. Retrieved 10 June 2020.
7. "Taiwan Cargo Plane Crashes, Pilots Missing". china.org.cn. 23 December 2002. Retrieved 8 July 2024.

External links

Aviation Safety Council

• TransAsia Airways GE791 Occurrence
  • TransAsia Airways Flight GE 791 Occurrence Final Report Volume I (Main portion of the report)
  • TransAsia Airways Flight GE 791 Occurrence Final Report Volume II (Appendices)
  • Interim recommendation

• TransAsia Airways GE791 Occurrence (in Chinese) – The Chinese version is the original version and version of reference
  • TransAsia Airways Flight GE 791 Occurrence Final Report Volume I (Main portion of the report)
  • TransAsia Airways Flight GE 791 Occurrence Final Report Volume II (Appendices)
  • Interim recommendation

• TransAsia Airways
• 2002 in Taiwan
• Accidents and incidents involving the ATR 72
• Aviation accidents and incidents in 2002
• Aviation accidents and incidents in Taiwan
• History of Penghu
• TransAsia Airways accidents and incidents
• Airliner accidents and incidents caused by ice
• Airliner accidents and incidents caused by pilot error
• December 2002 events in Asia
• 2002 disasters in Taiwan